- Di-tert-Butyl 3,3,5-trimethylcyclohexylidene diperoxide
- Peroxide, (3,3,5-Trimethylcyclohexylidene)bis[(1,1-dimethylethyl)
- Interox TMCH 40IC
- Luperox 231-50
- Trigonox 29
Unstable solid that is commonly blended with calcium carbonate and silica.
Registry Numbers and Inventories.
Japan ENCS (MITI)
Melting point, °C
Boiling point, °C
Vapor density (air=1)
Solubility in water
Partition coefficient, pKow
Hazards and Protection.
Regrigerate. Keep in a tightly closed container.
All chemicals should be considered hazardous. Avoid direct physical contact. Use appropriate, approved safety equipment. Untrained individuals should not handle this chemical or its container. Handling should occur in a chemical fume hood.
Wear protective gloves and clothing and safety goggles.
Follow the OSHA respirator regulations found in 29CFR 1910.134 or European Standard EN 149. Always use a NIOSH or European Standard EN 149 approved respirator when necessary.
ELIMINATE all ignition sources (no smoking, flares, sparks or flames in immediate area). Keep combustibles (wood, paper, oil, etc.) away from spilled material. Do not touch damaged containers or spilled material unless wearing appropriate protective clothing. Keep substance wet using water spray. Stop leak if you can do it without risk. SMALL SPILLS: Take up with inert, damp, noncombustible material using clean non-sparking tools and place into loosely covered plastic containers for later disposal.
Unstable. Self ignition is possible.
Organic compounds can ignite on contact with concentrated peroxides, strongly reduced material such as sulfides, nitrides, and hydrides
Self ignition is possible.
SMALL FIRES: Water spray or fog is preferred; if water not available use dry chemical, carbon dioxide or regular foam. LARGE FIRES: Flood fire area with water from a distance. Use water spray or fog; do not use straight streams. Move containers from fire area if you can do it without risk. Do not move cargo or vehicle if cargo has been exposed to heat. Fight fire from maximum distance or use unmanned hose holders or monitor nozzles. Cool containers with flooding quantities of water until well after fire is out. ALWAYS stay away from tanks engulfed in fire. For massive fire, use unmanned hose holders or monitor nozzles; if this is impossible, withdraw from area and let fire burn.
May be ignited by heat, sparks or flames. May burn rapidly with flare-burning effect.
May explode from heat, shock, friction or contamination. May ignite combustibles (wood, paper, oil, clothing, etc.). May be ignited by heat, sparks or flames. May burn rapidly with flare-burning effect. Containers may explode when heated. Runoff may create fire or explosion hazard.
Emits toxic fumes upon combustion.
May cause severe injury or burns.
If swallowed, do not induce vomiting. Seek medical assistance.
Move to fresh air. If breathing becoms difficult, seek madical assistance.
Get medical aid. Flush skin with plenty of soap and water for at least 15 minutes while removing contaminated clothing and shoes. Wash clothing before reuse.
Immediately flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Get medical aid.