1,12-Diisocyanatododecane

  • 1,12-Dodecane diisocyanate
  • Dodecamethylene diisocyanate
  • Isocyanic acid, dodecamethylene ester
Formula
C14H24N2O2
Structure
Description
Colorless liquid. Gasoline-like odor.

Registry Numbers and Inventories.
CAS
13879-35-1
UN (DOT)
2206
Beilstein/Gmelin
1784733
Beilstein Reference
4-04-00-01377

Properties.
Formula
C14H24N2O2
Formula mass
252.35
Boiling point, °C
135 (0.08 torr)
Vapor density (air=1)
8.70
Density
0.94 g/cm3
Solubility in water
Insoluble

Hazards and Protection.
Storage
Store in a tightly closed container. Store in a cool, dry, well-ventilated area away from incompatible substances. Store protected from moisture.
Handling
Avoid breathing dust, vapor, mist, or gas. Avoid contact with eyes, skin, and clothing. Keep container tightly closed. Use with adequate ventilation. Do not allow contact with water. Wash clothing before reuse. Keep from contact with moist air and steam.
Protection
Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHA's eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166. Skin: Wear appropriate protective gloves to prevent skin exposure. Clothing: Wear appropriate protective clothing to prevent skin exposure.
Respirators
A respiratory protection program that meets OSHA's 29 CFR 1910.134 and ANSI Z88.2 requirements or European Standard EN 149 must be followed whenever workplace conditions warrant a respirator's use.
Small spills/leaks
Absorb spill with inert material, (e.g., dry sand or earth), then place into a chemical waste container. Avoid runoff into storm sewers and ditches which lead to waterways. Clean up spills immediately, using the appropriate protective equipment. Remove all sources of ignition. Provide ventilation. Do not get water inside containers.
Stability
Stable at room temperature in closed containers under normal storage and handling conditions.
Incompatibilities
Moisture, strong oxidizing agents.
Decomposition
Nitrogen oxides, carbon monoxide, irritating and toxic fumes and gases, carbon dioxide.

Fire.
Flash Point,°C
> 110
Fire fighting
Wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. Containers may explode when heated. Extinguishing media: Do NOT get water inside containers. Cool containers with flooding quantities of water until well after fire is out. In case of fire use water spray, dry chemical, carbon dioxide, or appropriate foam.
Fire potential
HIGHLY FLAMMABLE: Will be easily ignited by heat, sparks or flames.
Hazards
Vapors form explosive mixtures with air: indoors, outdoors, and sewers explosion hazards. Most vapors are heavier than air. They will spread along ground and collect in low or confined areas (sewers, basements, tanks). Vapors may travel to source of ignition and flash back. Substance will react with water (some violently) releasing flammable, toxic or corrosive gases and runoff.
Combustion products
Fire will produce irritating, corrosive and/or toxic gases.
Health
2
 
Flammability
1
 
 
Reactivity
0
 

Health.
Exposure effects
Chronic overexposure to isocyanates has been reported to cause lung damage, including decreased lung fuction, which may be permanent.
   Ingestion
May cause gastrointestinal irritation with nausea, vomiting and diarrhea. The toxicological properties of this substance have not been fully investigated.
   Inhalation
Causes respiratory tract irritation. The toxicological properties of this substance have not been fully investigated. At high concentrations, isocyanates affect mucous membranes of the respiratory tract and may lead to fatal pulmonary edema. Exposure to low and often even unmeasurable isocyanate concentration results in sensitization.
   Skin
Causes skin irritation. Organic isocyanates can cause local irritation and allergic reactions.
   Eyes
Causes eye irritation.

First aid
 
   Ingestion
Never give anything by mouth to an unconscious person. Get medical aid. Do NOT induce vomiting. If conscious and alert, rinse mouth and drink 2-4 cupfuls of milk or water. Wash mouth out with water.
   Inhalation
Remove from exposure to fresh air immediately. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical aid. DO NOT use mouth-to-mouth respiration. If breathing has ceased apply artificial respiration using oxygen and a suitable mechanical device such as a bag and a mask.
   Skin
Get medical aid. Flush skin with plenty of soap and water for at least 15 minutes while removing contaminated clothing and shoes. Wash clothing before reuse.
   Eyes
Immediately flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Get medical aid.

Transport.
UN number
2206
Response guide
Hazard class
6.1
Packing Group
II; III