- Phenol, 2,4-dinonyl-
In preparation of lubricating oil additives, resins, plasticizers, surface active agents nonylphenol.
Registry Numbers and Inventories.
Japan ENCS (MITI)
Melting point, °C
Boiling point, °C
Solubility in water
Partition coefficient, pKow
Hazards and Protection.
Keep in a cool, dry, dark location in a tightly sealed container or cylinder. Keep away from incompatible materials, ignition sources and untrained individuals. Secure and label area. Protect containers/cylinders from physical damage.
All chemicals should be considered hazardous. Avoid direct physical contact. Use appropriate, approved safety equipment. Untrained individuals should not handle this chemical or its container. Handling should occur in a chemical fume hood.
Wear appropriate protective gloves, clothing and goggles.
Wear positive pressure self-contained breathing apparatus (SCBA).
ELIMINATE all ignition sources. Do not touch damaged containers or spilled material unless wearing appropriate protective clothing. Stop leak if you can do it without risk. Absorb or cover with dry earth, sand or other non-combustible material and transfer to containers. DO NOT GET WATER INSIDE CONTAINERS.
Small Fires: Dry chemical, carbon dioxide or water spray. Large Fires: Dry chemical, carbon dioxide, alcohol-resistant foam or water spray.
Combustible material: may burn but does not ignite readily.
When heated, vapors may form explosive mixtures with air: indoors, outdoors, and sewers explosion hazards.
Fire may produce irritating, corrosive and/or toxic gases.
Abnormally low blood pressure, reduced body temperature, rapid breathing, and rapid heart rate may develop with severe toxicity. Initial CNS excitation, including seizures, is commonly followed by CNS depression ranging from lethargy to coma and death. Fetotoxicity and skeletal abnormalities have been reported in animal experiments.
Phenol is extremely corrosive and may cause oral and esophageal burns and abdominal pain following ingestion.
Tachypnea is commonly reported; pulmonary edema and bronchospasm may also occur. Stridor has been reported from exposure to high concentrations of phenol. Respiratory arrest occurred 30 minutes post ingestion of 26.7 Grams of phenol in one case.
Phenol is corrosive to the skin, but because of anesthetic qualities, it will numb rather than causing a burning pain on contact. Skin becomes red and swollen, then white and opaque. Deep burns result that may become gangrenous.
Dilution - may enhance absorption of phenol, and should be avoided. Emesis: ipecac-induced vomiting is not recommended because of the potential for cns depression and seizures. Activated charcoal - may limit systemic toxicity if administered soon after ingestion, but may interfere with endoscopic evaluation of gastrointestinal burns.
Move patient to fresh air. Monitor for respiratory distress. If cough or difficulty breathing develops, evaluate for respiratory tract irritation, bronchitis, or pneumonitis. Administer oxygen and assist ventilation as required. Treat bronchospasm with beta2 agonist and corticosteroid aerosols.
Remove phenol with undiluted polyethylene glycol 300 to 400 or isopropyl alcohol prior to washing, if readily available. Wash exposed areas twice with large quantities of water. A physician may need to examine the exposed area if irritation or pain persist after the area is washed.
Irrigate exposed eyes with copious amounts of tepid water for at least 15 minutes. If irritation, pain, swelling, lacrimation, or photophobia persist, the patient should be seen in a health care facility.