4-Methyl-1,3-dioxane

  • 4-Methyl-m-dioxane
Formula
C5H10O2
Structure
Description
Colorless liquid.

Registry Numbers and Inventories.
CAS
1120-97-4
EC (EINECS/ELINCS)
214-323-1
RTECS
JH2200000
RTECS class
Mutagen
UN (DOT)
1993
Beilstein/Gmelin
102735
Beilstein Reference
5-19-01-00054
Japan ENCS (MITI)
Listed

Properties.
Formula
C5H10O2
Formula mass
102.13
Melting point, °C
-44.5
Boiling point, °C
113 - 114
Vapor pressure, mmHg
24 (25 C)
Vapor density (air=1)
3.52
Density
0.9667 g/cm3 (20 C)
Solubility in water
Very soluble
Surface tension
29.5 g/s2 (20 C)
Refractive index
1.4155
Partition coefficient, pKow
-0.14
Heat of vaporization
33.8 kJ/mol

Hazards and Protection.
Storage
Keep away from heat, sparks, and flame. Keep away from sources of ignition. Store in a tightly closed container. Store in a cool, dry, well-ventilated area away from incompatible substances. Flammables-area. Storage under a nitrogen blanket has been recommended. Store protected from light.
Handling
Use with adequate ventilation. Ground and bond containers when transferring material. Use spark-proof tools and explosion proof equipment. Avoid contact with eyes, skin, and clothing. Empty containers retain product residue, (liquid and/or vapor), and can be dangerous. Keep container tightly closed. Avoid contact with heat, sparks and flame. Avoid ingestion and inhalation. Do not pressurize, cut, weld, braze, solder, drill, grind, or expose empty containers to heat, sparks or open flames.
Protection
Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHA's eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166. Skin: Wear appropriate protective gloves to prevent skin exposure. Clothing: Wear appropriate protective clothing to prevent skin exposure.
Respirators
A respiratory protection program that meets OSHA's 29 CFR 1910.134 and ANSI Z88.2 requirements or European Standard EN 149 must be followed whenever workplace conditions warrant a respirator's use.
Small spills/leaks
Absorb spill with inert material, (e.g., dry sand or earth), then place into a chemical waste container. Avoid runoff into storm sewers and ditches which lead to waterways. Clean up spills immediately, using the appropriate protective equipment. Remove all sources of ignition. Use a spark-proof tool. Provide ventilation. A vapor suppressing foam may be used to reduce vapors.
Stability
On long term storage, substances with similar functional groups form explosive peroxides. May form peroxides in the absence on inhibitors Peroxide formation may occur in containers that have been opened and remain in storage.
Incompatibilities
Oxidizing agents.
Decomposition
Carbon monoxide, irritating and toxic fumes and gases, carbon dioxide.

Fire.
Flash Point,°C
22
Fire fighting
Wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. During a fire, irritating and highly toxic gases may be generated by thermal decomposition or combustion. Will burn if involved in a fire. Use water spray to keep fire-exposed containers cool. Water may be ineffective. Material is lighter than water and a fire may be spread by the use of water. Containers may explode in the heat of a fire. May form explosive peroxides. Extinguishing media: For small fires, use dry chemical, carbon dioxide, water spray or alcohol-resistant foam. For large fires, use water spray, fog, or alcohol-resistant foam. Use water spray to cool fire-exposed containers. Water may be ineffective.
Fire potential
HIGHLY FLAMMABLE: Will be easily ignited by heat, sparks or flames.
Hazards
Vapors may form explosive mixtures with air. Vapors may travel to source of ignition and flash back. Most vapors are heavier than air. They will spread along ground and collect in low or confined areas (sewers, basements, tanks). Vapor explosion hazard indoors, outdoors or in sewers.
Combustion products
Fire may produce irritating, corrosive and/or toxic gases.
Health
1
 
Flammability
3
 
 
Reactivity
0
 

Health.
Exposure effects
   Ingestion
May cause irritation of the digestive tract. The toxicological properties of this substance have not been fully investigated.
   Inhalation
May cause respiratory tract irritation. The toxicological properties of this substance have not been fully investigated. Vapors may cause dizziness or suffocation.
   Skin
May cause skin irritation.
   Eyes
May cause eye irritation.

First aid
 
   Ingestion
Never give anything by mouth to an unconscious person. Get medical aid. Do NOT induce vomiting. If conscious and alert, rinse mouth and drink 2-4 cupfuls of milk or water.
   Inhalation
Remove from exposure to fresh air immediately. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical aid.
   Skin
Get medical aid. Flush skin with plenty of soap and water for at least 15 minutes while removing contaminated clothing and shoes. Wash clothing before reuse.
   Eyes
Flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Get medical aid.

Transport.
UN number
1993
Response guide
Hazard class
3
Packing Group
I; II; III