N,N'-Bis(2-chloroethyl)-N-nitrosourea

  • 1,3-Bis(2-chloroethyl)-1-nitrosourea
  • Carmustine
  • Nitrumon
  • NSC 409962
  • Gliadel
  • BCNU
Formula
C5H9Cl2N3O2
Structure
Description
Orange-yellow solid.

Registry Numbers and Inventories.
CAS
154-93-8
EC (EINECS/ELINCS)
205-838-2
RTECS
YS2625000
RTECS class
Tumorigen; Drug; Mutagen; Reproductive Effector; Human Data
Merck
12,1894
Beilstein/Gmelin
2049744
Austrailia AICS
Listed

Properties.
Formula
C5H9Cl2N3O2
Formula mass
214.05
Melting point, °C
30-32
Boiling point, °C
404
Critical temperature
601
Critical pressure
36.7
Solubility in water
Slightly soluble
pKa/pKb
10.19 (pKa)
Partition coefficient, pKow
1.11

Hazards and Protection.
Storage
Keep in a cool, dry, dark location in a tightly sealed container or cylinder. Keep away from incompatible materials, ignition sources and untrained individuals. Secure and label area. Protect containers/cylinders from physical damage.
Handling
All chemicals should be considered hazardous. Avoid direct physical contact. Use appropriate, approved safety equipment. Untrained individuals should not handle this chemical or its container. Handling should occur in a chemical fume hood.
Protection
Chemical splash goggles in compliance with OSHA regulations are advised; however, OSHA regulations also permit other type safety glasses. Whre chemical resistant gloves. To prevent repeated or prolonged skin contact, wear impervious clothing and boots.
Respirators
Wear a NIOSH-approved half face respirator equipped with a combination filter cartridge, i.e. organic vapor/acid gas/HEPA (specific for organic vapors, HCl, acid gas, SO2 and a high efficiency particulate filter).
Small spills/leaks
Should a spill occur while you are handling this chemical, FIRST REMOVE ALL SOURCES OF IGNITION, then you should dampen the solid spill material with 60-70% ethanol and transfer the dampened material to a suitable container. Use absorbent paper dampened with 60-70% ethanol to pick up any remaining material. Seal the absorbent paper, and any of your clothes, which may be contaminated, in a vapor-tight plastic bag for eventual disposal. Solvent wash all contaminated surfaces with 60-70% ethanol followed by washing with a soap and water solution. Do not reenter the contaminated area until the Safety Officer (or other responsible person) has verified that the area has been properly cleaned.
Stability
No data.

Fire.
Fire fighting
Fires involving this material can be controlled with a dry chemical, carbon dioxide or Halon extinguisher.
Fire potential
This material is probably combustible.

Health.
Carcinogin
I-2A, N-2, CP65
Exposure effects
   Ingestion
See inhalation.
   Inhalation
Symptoms of exposure to this compound may include bone-marrow suppression; delayed onset of leukopenia and thrombocytopenia; cytotoxic effects on the liver, kidneys and central nervous system; nausea; vomiting; flushing of the skin; esophagitis; diarrhea; dyspnea and hepatotoxicity.
   Skin
See inhalation.
   Eyes
See inhalation

First aid
 
   Ingestion
If the victim is conscious and not convulsing, give 1 or 2 glasses of water to dilute the chemical and IMMEDIATELY call a hospital or poison control center. MMEDIATELY transport the victim to a hospital.
   Inhalation
IMMEDIATELY leave the contaminated area; take deep breaths of fresh air. IMMEDIATELY call a physician and be prepared to transport the victim to a hospital even if no symptoms (such as wheezing, coughing, shortness of breath, or burning in the mouth, throat, or chest) develop. Provide proper respiratory protection to rescuers entering an unknown atmosphere. Whenever possible, Self-Contained Breathing Apparatus (SCBA) should be used.
   Skin
IMMEDIATELY flood affected skin with water while removing and isolating all contaminated clothing. Gently wash all affected skin areas thoroughly with soap and water. If symptoms such as redness or irritation develop, IMMEDIATELY call a physician and be prepared to transport the victim to a hospital for treatment.
   Eyes
First check the victim for contact lenses and remove if present. Flush victim's eyes with water or normal saline solution for 20 to 30 minutes while simultaneously calling a hospital or poison control center. Do not put any ointments, oils, or medication in the victim's eyes without specific instructions from a physician. IMMEDIATELY transport the victim after flushing eyes to a hospital even if no symptoms (such as redness or irritation) develop.

Transport.